Long overdue update

The respray was completed and the Golf came home but was not running at all well. We decided that the fuel distribution box was at fault and tried a couple of other units in the car but there wasn't much success.

It took some investigation to locate someone with the right skills and tools to diagnose the problems correctly. I ended up taking the car to Richards Bros. in Redruth as they still have the Bosch diagnostics equipment available. In the end the whole fuel system from the fuel tank (full of rubbish and a non-functioning low pressure pump) through pipes that needed replacing in sections to the fuel distributor that had to be sent for reconditioning and new injectors was reviewed and rebuilt. Once that was done problems were found with the cold-start and warm-start sensors so they were replaced too.

The car was running superbly from late 2015.

With a driving holiday in France planned there was some frantic scheduling of the new roof being fitted and getting a stereo in place and working. We covered 1000 miles in the week and had a wonderful time with the roof down most days. The car was faultless until the last day when a misfire appeared and we were down on power. We limped home under our own power but I think a trip back to Richards Bros is in the future to diagnose what has happened.

Still remaining on the list to do:

• Refurbish wheels - I now have 8 so need to pick the best 4 and send them off to be soda blasted and then fully renovated
• Repair and renovate interior. Front seats need re-padding, rears just need a good clean
• Suspension
• Engine - still a nagging oil leak here and there so new gaskets needed
• Dash - the mfa seems to have gone AWOL.
• Seats - the runners are not sliding quite right.

The move from the barn to the garage

So, we get the weather for a few days that means the ground outside the barn starts to dry out so we head up there with the truck, a strong rope and a bunch of bailer twine.

The plan is, drag the Golf out of the barn (backwards) and then ... well, that was pretty much the extent of the plan. I had no idea whether it would tow that far let alone what we would do next. We only had the truck and some rope so pushing was not an option - I could only pull.

We started by putting a loop of twine through the tow loop on the Golf so that we could get the rope through it, tied the other end of the rope to the truck tow hitch and drove off. The rope snapped after maybe 10'. The Golf had reached a pile of hay and rather than go up and over it stopped. We rolled the car forwards and clear some of the hay away. I tied the ends of the rope together and we set off again. Another car length and the rope snapped again. This time it was as the front wheels met the pile of hay. With some stearing lock applied as well as the rise in height was too much for the rope. This time we didnt clear any hay as that wasnt an option so we rolled forwards and took a run up at the pile. We rolled up and over quite neatly.

We now had to get around the tree outside the barn. This was causing me to have to tow from a slight angle and I was also having to steer to avoid other obstacles and try to find grip through some 6" of mud. After a few yards it became too close to keep going and we had to stop towing. It was now a case of manually pushing the car forwards to that we could get the steering lock on enough to avoid the tree. We managed maybe 2'-3' at best. The car was bogging down and we were slipping badly in the mud. I towed it forwards the 2'-3' and we 'reversed' it again. This time we got it clear enough to tow past the tree but it was still going over some of the roots and we managed to snap the rope, again. After this was retied we got all the way past the tree and were venturing into uncharted territory.

It was now necessary to get the truck on the other end of the Golf to head back towards the road, and the 1:8 hill that we had to descend. This was mostly a concrete section so was pretty easy going. I drove the truck and my wife was in charge of steering the Golf. Simples.

Going down the hill was the next hurdle, we had no idea if the brakes would work so I tied the tow–rope to the back of the Golf again and lowered it down the hill with the truck behind it. Piece of cake as it turned out – we didn't meet any traffic and coasted gently to the foot of the hill where I swapped the truck back to the front to tow it to the house and then into the garage.

-- NOTE-- This happened in March 2009 and I have only now (June 2010) re-started the project and found this update un-posted. Oops, must try harder.

Day one (ish)

Yesterday I spent the whole day clearing out the garage. It had been the default place to dump anything that didnt have a proper home for pretty much the last 18 months. It took all day and I had to be brutal about throwing stuff out. Why? Because today it was going to have a car put in it. As it happens it didnt but that gives me the chance to give you some of the back story and the reason for this blog.

I bought the car back in (ages ago, I cant remember when but probably 2003 or 2004). Its a Volkswagen Golf GTi Cabriolet - anyone from the US will know it as a VW Rabbit. We ran it for a year but it was getting vandalised and we decided to take it of the road. Luckily some friends of ours had a barn we could use to store it. well the time came to use the barn for barn like activities and we had to get the car moved. This coincided with us move house too so the car took up residence in another barn, just behind our horses stables. The car was not drivable at this point due to the battery going flat and the immobiliser , um , ... immobilising it. The brakes on one wheel had become seized too but that was sorted with a few swift swipes of a mallet.

this morning I went to the barn with the aim of towing it out with the pickup and then towing it into my newly empty (ish) garage. I got nowhere. 3 brakes are now seized so I am a bit stuck. I am going to look for advice from some local mechanics, the Haynes manual people and the Golf owners club. The barn isnt really big enough to renew the brakes where it is and I dont have all the tools to hand either.

I will try to post photos and keep things up to date here as I work on renovating the car and getting it back to the way it should be.